Product ID:PORTER CABLE TENA-FILM GREASE 300-1
MSDS Date:01/14/1986
FSC:6850
NIIN:00N011441
MSDS Number: BJKGH

Emergency Phone: 502-769-3385

Info Phone: 502-769-3385

Preparer: DEBBIE DUNN

Cage: 58149

Telephone: 502-769-3385

Cage: 58149

SODIUM NITRITE (SARA III)

CAS: 7632-00-0

RTECS: RA1225000

Fraction By Weight: 0.75%

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:REPEATED/PROLONGED CONTACT WITH SKIN
MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:PRODUCT CONTACT MAY CAUSE
IRRITATION.SKIN:PROLONGED/REPEATED CONTACT TENDS TO REMOVE SKIN
OILS POSSIBLY LEADING TO IRRITATION AND
DERMATITIS.INHALATION/INGESTION:N/K .
Medical Cond Aggravated by Exposure:N/K

First Aid:EYES:FLUSH W/ CLEAR WATER FOR AT LEAST 15 MIN OR UNTIL IRRIT
SUBSIDES.IF IRRIT PERSISTS,CALL PHYSICIAN.SKIN:REMOVE CONTAM CLTHG
& WASH SKIN THOROUGHLY W/ SOAP & WATER.INGEST:CALL MD
IMMEDIATELY.INHAL: VAPOR PRESSURE IS VERY LOW,INHAL UNDER AMBIENT
CONDITIONS IS NOT A PROBLEM.IF OVERCOME BY VAPOR FROM HOT
PRODUCT,REMOVE FROM EXPOSURE AND CALL MD.IF BRTHG IS IRREGULAR OR
STOPPED START RESUSCITATION.

Flash Point Method:COC
Flash Point:SEE SUPP DATA
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:FOAM,DRY CHEMICAL,CARBON DIOXIDE,WATER SPRAY,WATER
FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .USE WATER SPRAY TO COOL FIRE-EXPOSED SURFACES
AND TO PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE W/ STRONG OXIDANTS
LIKE LIQ CHLORINE OR CONC OXYGEN.HAZ DECOMP
PROD:FUMES,SMOKE,ALDEHYDES,OXIDES OF CARBON & NITROGEN IN
INCOMPLETE COMBUST.

Spill Release Procedures:LUBRICATING GREASE IS SLIPPERY AND SHOULD BE
IMMEDIATELY REMOVED IF SPILLED.SHOVEL OR SCRAPE EXCESS.COVER AREA
WITH FULLER EARTH-TYPE OIL ABSORBENT,SAND OR SAWDUST.RESIDUE CAN BE
REMOVED WITH EMULSION CLEANERS.
Neutralizing Agent:N/K

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN
USE.STORE IN CLEAN AREA AND PROTECT FROM AIRBORNE DUST AND FOREIGN
MATERIAL.KEEP AWAY FROM OPEN FLAMES.
Other Precautions:NONE

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Protective Gloves:NORMALLY NOT REQUIRED.
Eye Protection:CHEM WORK GOGG,FACESHLD OPTIONAL .
Other Protective Equipment:WEAR OIL-IMPERVIOUS APRON IF PRODUCT IS
LIKELY TO CONTACT CLOTHING DURING WORKING PROCEDURES.
Work Hygienic Practices:N/K
Supplemental Safety and Health
FLASH PT:450F,232.22C ON OIL COMPONENT.ROUTES OF
ENTRY:INHALATION/SKIN/INGESTION .

Boiling Pt:B.P. Text:677F,358.8C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:<0.01 MMHG
Vapor Density:>5,AIR=1
Spec Gravity:0.90 (WATER=1)
Evaporation Rate & Reference:<0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER-YELLOW BUTTERY GEL,NLGI NO 1
CONSISTENCY.MILD,BLAND PETROLEUM ODOR.
Percent Volatiles by Volume:NEGLIG

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID EXPOSURE TO OPEN FLAME.
Hazardous Decomposition Products:FUMES,SMOKE,ALDEHYDES,OXIDES OF CARBON
AND NITROGEN IN CASES OF INCOMPLETE COMBUSTION.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATE IN AN APPROVED
MANNER OR USE APPROVED LANDFILL FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.